HOLT LLOYD CORP (FORMERLY L P S LABORATORIES) -- LPS 1 GREASELESS LUBRICANT  -- 9150-00-241-7006
<pre>=====================  Product Identification  =====================

Product ID:LPS 1 GREASELESS LUBRICANT
MSDS Date:03/01/1989
FSC:9150
NIIN:00-241-7006
=== Responsible Party ===
Company Name:HOLT LLOYD CORP (FORMERLY L P S LABORATORIES)
Address:4647 HUGH HOWELL ROAD
City:TUCKER
State:GA
ZIP:30084-5096
Country:US
Info Phone Num:404-934-7800
Emergency Phone Num:404-934-7800
Preparer's Name:JOE TARPLEY
CAGE:32861
=== Contractor Identification ===
Company Name:HOLT LLOYD CORP
Address:4647 HUGH HOWELL RD
Box:City:TUCKER
State:GA
ZIP:30084-5004
Country:US
Phone:404-934-7800
CAGE:32861
Company Name:LPS LABORATORIES,	INC.
Address:4647 HUGH HOWELL ROAD
Box:City:TUCKER
State:GA
ZIP:30085-5052
Country:US
Phone:404-934-7800
CAGE:66724

=============  Composition/Information on Ingredients  =============

Ingred Name:ALIPHATIC PETROLEUM DISTILLATE [ALIPHATIC HYDROCARBON]
CAS:64742-96-7
Fraction by Wt: 70-80%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:100 PPM
ACGIH TLV:100 PPM

Ingred Name:ALIPHATIC PETROLEUM NAPHTHA (MINERAL SEAL OIL)
CAS:64742-30-9
Fraction by Wt: 20-30%
Other REC Limits:NONE RECOMMENDED

Ingred Name:NON-HAZARDOUS PROPRIETARY BLEND
Fraction by Wt: 3-5%
Other REC Limits:NONE RECOMMENDED

Ingred Name:CARBON DIOXIDE (PROPELLANT)
CAS:124-38-9
RTECS #:FF6400000
Fraction by Wt: 2-3%
Other REC Limits:NONE RECOMMENDED
OSHA PEL:5000 PPM
ACGIH TLV:5000PPM/30000STEL;94

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:ACUTE: INHALATION MAY CAUSE CNS
    EFFECTS. CONTACT WITH EYES MAY CAUSE IRRITATION. ASPIRATION OF
    PRODUCT INTO LUNG MAY CAUSE CHEMICAL PNEUMOCONIOSIS, LUNG DAMAGE OR
    DEATH. CHRONIC: PROLONGED OR REPEATED  SKIN CONTACT MAY CAUSE
    DRYING OF SKIN.
Explanation of Carcinogenicity:NO INGREDIENT OF A CONCENTRATION OF 0.1%
    OR GREATER IS LISTED AS A CARCINOGEN OR SUSPECTED CARCINOGEN.
Effects of Overexposure:INHALED: HEADACHE, DIZZINESS, NAUSEA,
    ANESTHETIC EFFECTS. SKIN: DRY SKIN. EYES: REDNESS, TEARS,
    DISCOMFORT.
Medical Cond Aggravated by Exposure:NONE FROM NORMAL EXPOSURE.

=======================  First Aid Measures  =======================

First Aid:EYES: FLUSH WITH LOTS OF COLD WATER AND CONTACT DOCTOR. SKIN:
    WASH WITH SOAP AND WATER & THEN APPLY MEDICATED SKIN CREAM.
    INHALED: MOVE TO FRESH AIR AND CONTACT DOCTOR. INGESTED: DO NOT
    INDUCE VOMITIN G. CONTACT DOCTOR IMMEIDATELY.

=====================  Fire Fighting Measures  =====================

Flash Point:175F,79C
Lower Limits:1
Upper Limits:6
Extinguishing Media:FOAM, CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:DO NOT USE WATER. TREAT AS COMBUSTIBLE
    PERTROLEUM DISTILLATE. HMIS-WEAR SELF-CONTAINED BREATHING APPARATUS
    AND BUNKER GEAR.
Unusual Fire/Explosion Hazard:EXCESSIVE HEAT CAUSED BY FIRE WILL CAUSE
    AERESOLS TO BURST.

==================  Accidental Release Measures  ==================

Spill Release Procedures:VENTILATE AREA. ELIMINATE ALL SOURCES OF
    IGNITION. REMOVE LEAKING CONTAINER AND TRANSFER PRODUCT TO ANOTHER
    CONTAINER. PREVENT RUNOFF INTO SEWERS & WATERWAYS. USE APPROPRIATE
    SAFETY EQUIPMENT. MOP UP  OR SOAK UP RESIDUE W/ABSORBENT MATERIAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE AEROSOLS IN A CLEAN, DRY,
    WELL-VENTILATED AREA BELOW 120F AND ABOVE 32F. STORE AWAY FROM
    SOURCES OF IGNITION AND INCOMPATIBLE MATERIALS.
Other Precautions:AVOID BREATHING VAPORS.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NONE NORMALLY REQUIRED. IF ENGINEERING CONTROLS
    FAIL OR EMERGENCY OCCURS; USE NIOSH/MSHA APPROVED RESPIRATOR OR
    SUPPLIED AIR RESPIRTATOR OR SCBA, AS REQUIRED. USE IAW 29 CFR
    19120.134.
Ventilation:USE LOCAL EXHAUST OR GOOD GENERAL MECHANICAL VENTILATION TO
    MAINTAIN EXPOSURE BELOW PEL/TLV.
Protective Gloves:NITRILE, BUTYL, PVA
Eye Protection:FACE SHIELD OR SAFETY GOGGLES
Other Protective Equipment:NONE, SPECIFIED BY MANUFACTURER. HMIS- EYE
    WASH AVAILABLE.
Work Hygienic Practices:WASH HANDS AFTER USE AND BEFORE EATING,
    DRINKING, OR SMOKING. LAUNDER CONTAMINATED CLOTHES BEFORE REUSE.
Supplemental Safety and Health

==================  Physical/Chemical Properties  ==================

HCC:V3
Boiling Pt:B.P. Text:350F,177C
Vapor Pres:<2 MM HG
Vapor Density:4.7
Spec Gravity:0.80
Evaporation Rate &amp; Reference:0.07 (N-BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:CLEAR, THIN LIQUID WITH SWEET ODOR
Percent Volatiles by Volume:95

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS LIQUID CHLORINE, CONCENTRATED OXYGEN,
    OR SODIUM HYPOCHLORITE.
Stability Condition to Avoid:AVOID SPARKS OR OPEN FLAME. HMIS-AVOID
    EXPOSURE/CONTACT WITH INCOMPATIBLE MATERIALS.
Hazardous Decomposition Products:THERMAL DECOMPOSITION MAY YEILD CARBON
    MONOXIDE AND CARBON DIOXIDE.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND
    FEDERAL REGULATIONS. EPA WASTE NUMBER DOO1 MAY APPLY.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.